|
Compressor VV 0,8/8-720
Compressor is intended for compressed air feed of brake systems and pneumatic units of wide and narrow gage industrial diesel locomotives, diggers, itinerary technique.
On application of a customer are delivered the compressors of various modifications:
- with double-strand, three-strand or single-diameter block;
- with left-side or right-hand installation of filter.
Feature
Capability, m3/min |
0,8 |
Nominal (excessive) discharge pressure, MPa (kg/cm2) |
0,8 (8,0) |
Nominal bent shaft speed, S-1 (turn/min) |
12 (720) |
Overall dimensions, mm
length
width
height |
575
553
633 |
Mass, kg |
105 |
Compressor VG 0,58/8-540
Compressor is applied as a component of electric compressor EK7V.
Feature
Capability, m3/min |
0,58 |
Nominal (excessive) discharge pressure, MPa (kg/cm2) |
0,8 (8,0) |
Nominal bent shaft speed, S-1 (turn/min) |
9,0 (540) |
Overall dimensions, mm
length
width
height |
520
583
438 |
Mass, kg |
118 |
Compressor VG 0,42/8-400
Compressor is applied as a component of electric compressor EK4B-M.
Feature
Capability, m3/min |
0,42 |
Nominal (excessive) discharge pressure, MPa (kg/cm2) |
0,8 (8,0) |
Nominal bent shaft speed, S-1 (turn/min) |
6,7 (400) |
Overall dimensions, mm
length
width
height |
605
627
500 |
Mass, kg |
130 |
Compressor EK4-M
Compressor is applied as a component of air electric compressor EK4V-M.
Feature
Capability, m3/min |
0,4 |
 |
Nominal (excessive) discharge pressure, MPa (kg/cm2) |
0,8 (8,0) |
Nominal bent shaft speed, S-1 (turn/min) |
7,33 (440) |
Overall dimensions, mm
length
width
height |
520
583
465 |
Mass, kg |
130 |
Compressed air preparation system SPV 4,5/1,0
Compressed air preparation system SPV 4,5/1,0 is intended for compressed air preparation and draining from damp and dirt that fit the quality of the fifth contamination class according to GOST 17433-80.
Range of application: diesel locomotives, electric locomotives.
Setting in other places, where compressed air that is drained from damp and dirt and fits the quality of the fifth compressed air contamination class according to GOST 17433-80 is necessary, is feasible, too.
Feature
Airflow through SPV |
3.0…4.5 |
Excessive discharge pressure, MPa |
1.0 |
Air consumption for regeneration, %, no more than |
18 |
Resistance of SPV, MPa |
0.05 |
Outlet SPV dirt content in compressed air |
Particulate matter, mg/m3, no more than |
4 |
Oil, mg/m3, no more than |
10 |
Fluid damp |
No admissible |
Outlet SPV dew point of drained compressed air |
At change of its temperature from -25 to +65 degrees |
No less than by 5 ° degrees below the ambient temperature |
In the ambient temperature range from -25 to +55 degrees |
No more than -30 degrees |
Compressed air conversion system BO N 660
Compressed air preparation system is intended for compressed air preparation and draining from mineral oil, water and mechanical impurities before intake into pneumatic units and transportation systems.
Type of dehumidifier - adsorption, single-adsorption, full-flow, with integral primary preparation. For moisture absorption from air is provided secondary compressed air draining. Drain valve is electropneumatic.
Feature
Environment of dehumidifier |
Intermittent, according to compressor's environment |
Consumption of dried air that is corrected to conditions of absorption with the compressor, m3/min |
0,5 |
Operating pressure (excessive) of dried air, MPa, kg/cm2) |
0,4…0,8 (4,0…8,0) |
Degree of draining |
Outlet SPV temperature of dew point of compressed air shall be no less than by 5 ° below the ambient temperature |
Cutoff rating of air from oil, % |
90 |
Supply voltage of valve, V |
23-30 |
Capacity of valve, W |
60 |
Current, A |
Direct |
Overall dimensions, mm
length
width
height |
720
195
420 |
Mass, kg |
33 |
Air filter UF-2
Filter is intended for preparation of air that is absorbed with air compressors of rail transportation.
As the offers are received is fabricated for export.
Feature
Capability compressors on that the filter is settled, m3/min |
to 3,5 |
Overall dimensions, mm
length
width
height |
260
262
289 |
Mass, kg |
8,6 |
Damper filter EK7V.08.000-02
Damper filter is intended for preparation of air that is absorbed with air compressors of rail transportation.
Feature
Capability compressors on that the filter is settled, m3/min |
to 1,0 |
 |
Fineness of sifting, mcm |
40 |
Overall dimensions, mm
length
width
height |
415
207
235 |
Mass, kg |
7 |
Oil catcher E-120/T
Oil-catcher is intended for air preparation from water, mineral oil and other contaminating impurities in rolling stock systems by pressure to 1,0 MPa (10,0 kgc/cm2).
Feature
Cutoff rating of air, % |
70 |
Nominal pressure, MPa (kgc/cm2) |
1,0 (10,0) |
Nominal pressure difference, MPa (kgc/cm2) |
0,06 (0,6) |
Overall dimensions, mm
length
width
height |
235
226
305 |
Mass, kg |
16,9 |
Emergency valve 2-1
Emergency valve is intended for guard from relative height of air pressure in the inter-step cooler of compressor (after prime compression stage), in air systems of rolling stock and other objects.
Feature
Operating pressure (opening pressure) MPa (kgc/cm2) |
0,4±0,01 (4,0±0,1) |
 |
Closing pressure MPa (kgc/cm2), no less than |
0,32 (3,2) |
Overall dimensions, mm |
199 ´ 72 |
Mass, kg. no more than |
2,04 |
Emergency valve 2-2
Emergency valve is intended for guard from relative height of air pressure above the steady operating pressure in air systems of rolling stock and other objects.
Feature
Operating pressure (opening pressure) MPa (kgc/cm2) |
1,0±0,01 (10,0±0,1) |
 |
Closing pressure MPa (kgc/cm2), no less than |
0,8 (8,0) |
Overall dimensions, mm |
199 ´ 72 |
Mass, kg, no more than |
2,115 |
|
|
